Violet UVC Seoul Viosys LED Module 275nm 12 LEDs 152mW 11.69" 48VDC IP67 with controler incl., for disinfection

Highly efficient disinfection lamp for professional applications

The Violet UV-C LED module offers professional users a highly efficient solution for disinfection. The LEDs used in the UV-C lamp emit a radiation with 275nm wavelength and thus enable the disinfection of air, liquids and surfaces. Bacteria, germs and viruses can be reliably killed/inactivated in this way.

The product consists of the following components:

• LED module with 12  Seoul Viosys UVC LEDs (275nm)
• UVC radiant flux 270nm: 152mW at 48 VDC
• With built in Powercontroler V2 with DALI dimming and LED driver (48 VDC power supply required)
• Uses UVC rated lens for LEDIL, FN17294_VIOLET-12X1-S with 52 degree wide beam for each LED (available separately under article number 36480)
• Typical power consumption 12.72W at 48V
• Lens system made from silicone clear lens and stainless steel metal frame
• Robust aluminum housing
• UVC Module protection rating: IP67
• Dimensions: 11.69x1.75x1.29" ( 297.3x44.6x32.8 mm) (LxWXH)

In addition, the following application scenario can be realized with the included, compact PowerController V2:

A combination of a button, switch, motion sensor and the three signal LEDs already mentioned ensures that there are no people in the room where sterilization is to be performed. Only when the motion sensor registers no more movement after 10 seconds, the button is activated by closing the door and all safety conditions are fulfilled by a green signal LED, the UVC module can be activated via the switch.

The module is primarily aimed at the industrial sector, such as lighting manufacturers and companies in the medical technology sector.

The Violet UVC module has a radiated power of 152mW when operating at a typical voltage of 48VDC. 

The table below illustrates the surface irradiance with varying distances.

The following table* shows the irradiation time with a distance of 100 mm and an irradiation intensity of 0.81 mW/cm² on various microorganisms.

* The dosage stated in the table refers to a wavelength of 254 nm. The irradiation time was converted to the wavelength of this UVC module (275 nm) without taking the spectrum into account.

Note: This product is intended exclusively for customers who are trained in the use of UVC radiation and can ensure hazard-free use. Do you have further questions concerning this product or the topic UVC? Please send an e-mail to main@ledrise.com

Warnings

• The article is a powerful UVC module which can be used for the disinfection of surfaces. It emits at a wavelength of 280 nm which is not visible to the human eye.
• It is imperative to ensure that users wear suitable protective clothing against UV radiation at all times. All skin and eye contact must be avoided.
• We recommend the use of the following protective agents:
  • Safety goggles
  • Gloves
  • Face Shield
  • Protective clothing that shields UV light from the skin
• Wear protective clothing at all times during use and ensure that no other persons are within reach of the radiation source without taking appropriate safety precautions.
• Light can reflect, therefore special precautions have to be taken with reflecting surfaces (e.g. mirrors).
• If skin tissue is exposed to the light source, skin irritation comparable to sunburn may occur. If necessary, treat the affected areas with a suitable cream or consult a physician.
• Low wavelength UV light can cause permanent damage to the retina in severe cases. Make sure to wear protective goggles at all times when using the device.